You are here: Home > News > Content
Paper Construction Method Of Mix-pulp Paper Wipes Paper And Precautions
Jul 24, 2017



Paper construction method of Mix-pulp Paper Wipes paper and precautions

Mixed pulp paper wallpaper is also known Mix-pulp Paper Wipes wallpaper is a kind of upscale wallpaper/wallpaper, due to using natural plant fiber non-woven technology made more tension, more environmental protection, not moldy yellow, good permeability is the main base material of high quality wallpaper.

Paper paper:

1. Metope treatment

The metope requires level, clean, dry, the color is uniform, should be free of void, convex concave is not equal defect, the metope before construction should be done brush base film (or varnish) processing.

2. Wallpaper cutting

According to the serial number of the wallpaper will set the wallpaper, measuring the height of the wall, according to the height of the wall above and reserve 5 cm cutting wallpaper, bear in mind that a cutting out a roll of wallpaper, in case of quality problems.

3. Brush wallpaper glue

Paste the Mix-pulp Paper Wipes wallpaper glue must be brushed evenly on the metope, the thickness is in 2mm, must not be brushed with glue directly on the back of Mix-pulp Paper Wipes paper, more must not bubble water wet paste. Mix-pulp Paper Wipes paper is different from other wallpaper, should be thicker than other wallpaper glue, thick, make its liquidity drop.

4. Wall paper

Paste the paper wallpaper in a preset sequence.

5. Construction wallpaper cutting

Need to take the edge of the construction, the specific method is on during the construction, on how many depends on pattern, about 3 cm long, plain coloured mixed pulp paper adopts the method of positive and negative paste construction during construction, flowers model after ensure pattern alignment, the overlap with straightedge pressure, cutting, try to avoid in the Yang Angle cutting, Mix-pulp Paper Wipes lest cause Yang wallpaper become warped edge Angle, make sure the cutting blade when cutting, there shall be no burrs, at the same time pay attention to the strength under the knife, to ensure that a cutting, make a clean break, but also cannot too hurt the surface of the wall.

6. Clean the wallpaper after the paste

After construction, if the surface has dust, apply short brush or duster to gently brush, do not wipe with wet towel to cause pollution to expand.

Notes for paper wallpaper:

1. After the coating is dry at the base of the construction, the vertical line should be used to make the standard, so that the wallpaper paste should not be incorrect.

2, do not use hard after the wall paper on wall scraper or nylon brush, you should use soft brush to blow gently, Mix-pulp Paper Wipes by the surface flat of the mixed pulp paper, remove air bubbles, wrinkle, don't scrape the glue joint surface, so as to avoid pollution if gets out glue immediately with a dry towel to wipe clean, as far as possible when construction keep hands clean.

3. The construction should be inspected during the construction, and the problems should be stopped immediately to find out the reasons and solutions for the construction.

Products with mixed pulp of paper as raw material, it is a new generation of environmental protection material, has moisture-proof, breathable, flexible, qualitative light, no combustion, easy to decompose, non-toxic non-irritating, rich colors, Mix-pulp Paper Wipes with low cost, reusable, etc. It into outdoor 90 days, biodegradable materials in the service life for up to five years, when burning non-toxic, tasteless, and without any left over material, so as to not pollute the environment, is internationally recognized for protection of the earth's ecological environmental protection product.

Advantages:

1. Light weight: with polypropylene resin as the main raw material, the proportion is only 0.9, Mix-pulp Paper Wipes only three-fifths of cotton, with fluffy and good feeling.

2. Non-toxic and non-irritant: the products are produced by the food grade of the FDA, with no other chemical composition, stable performance, no toxicity, no smell, no irritation of the skin.

3. Antibacterial and anti-chemical agents: Mix-pulp Paper Wipes polypropylene is a chemical blunt substance, not worm-eaten, and can isolate the presence of bacteria and insects in the liquid. Antibacterial, alkali corrosion, finished products do not affect the strength due to erosion.

4. Good things. It is made of polypropylene spinning directly into mesh heat bonding, and the strength of the products is better than that of ordinary short fiber products.

5. In the aspect of environmental protection, Mix-pulp Paper Wipes the use of most of the mixed pulp paper raw material is polypropylene, and the raw material of plastic bags is polyethylene, although two substances similar name, but it is far on the chemical structure. The chemical molecular structure of polyethylene is very stable and extremely difficult to degrade, so it takes 300 years to decompose plastic bags. And the chemical structure of polypropylene is not strong, the molecular chain can easily break, which can effectively degrade, and environment in non-toxic form into the next cycle, a mixed pulp paper shopping bag can be completely decomposed in 90 days. And the Mix-pulp Paper Wipes paper shopping bags can be reused more than 10 times, and the pollution of the environment after disuse is only 10% of the plastic bag.